Hoshizaki KM-101BAH User Manual

SELF-CONTAINED CRESCENT CUBERINSTRUCTION MANUAL KM-61BAHKM-101BAHKM-151BAHKM-151BWHL1M006102 (100109)

7C. LocationWARNINGThis icemaker is not intended for outdoor use. Normal operating ambient temperature should be within +45°F to +100°F (+7°C to +38°

8* The icemaker requires no clearance at either side. But allow enough space at rear for water supply and drain connections, at least 12” (approx. 30

9F. Water Supply and Drain Connections - See Fig. 4CAUTIONTo prevent damage to equipment, do not operate this icemaker when the water supply is OFF, o

10* Drain lines should not be piped directly to the sewer system. An air gap of a minimum of 2 vertical inches (5 cm) should be between the end of th

11Fig. 5KM-151BWHIcemaking Water Supply Inlet 1/2” FPTBin Drain Outlet3/4” FPTCondenser Water Outlet 1/2” FPTCondenser Water Inlet 1/2” FPTShut-off Va

12G. Final Checklist1) Is the icemaker level?2) Is the icemaker in a site where the ambient temperature is within +45°F to +100°F (+7°C to +38°C) and

13H. StartupCAUTION1. All parts are factory-adjusted. Improper adjustments may result in failure.2. If the unit is turned off, wait for at least 3 mi

14III. Cleaning and Maintenance InstructionsIMPORTANTEnsure all components, fasteners and screws are securely in place after any maintenance or cleani

157) Same as step 4.8) Move the Control Switch to the “ICE” position to fill the Water Tank with water.9) After 3 minutes, move the Control Switch to t

1616) Wash the Bin Control Switch, Water Tank, Float Switch, Cube Guide, Silicone Hose and Overflow Pipe by using a nylon scouring pad, brushes and the

IMPORTANTOnly qualified service technicians should install, service and maintain the product. No installation, service or maintenance should be undert

173) Discard the sanitizing solution and rinse the parts thoroughly with water.4) Replace the removed parts in their correct positions in the reverse

183. Air FilterThe plastic mesh Air Filter removes dirt or dust from the air, and keeps the Condenser from getting clogged. As the filter gets clogged

198) Quickly blow the potable water supply line out using compressed air or carbon dioxide.2. Drain the potable Water Tank:1) Turn off the power suppl

IMPORTANT1. This booklet is an integral and essential part of the product and should be handed over to the user. Read the warnings contained in this

1I. SpecificationsA. Nameplate RatingModel Amperes Refrigerant ARI Energy StarKM-61BAH3.4 AMPS R134a 7.1 oz. Not applicable Not applicableKM-101BAH5.2

2B. Dimensions/Connections1. KM-61BAHUnit: mm [inches]

32. KM-101BAHUnit: mm [inches]

43. KM-151BAHUnit: mm [inches]

54. KM-151BWHUnit: mm [inches]

6II. Installation and Operating InstructionsA. Checks Before Installation* Visually inspect the exterior of the shipping container, and any severe dam